Product ID:E-57 EMULSIFIER
MSDS Date:01/01/1995
FSC:6850
NIIN:01-263-8227
Kit Part:Y
MSDS Number: CCSWY

Emergency Phone: 310-450-1111/800-424-9300(CHEMTREC)

Info Phone: 310-450-1111

Cage: 98733

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT REFINED

CAS: 64741-96-4

RTECS: PY8040001

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPORS OR
OIL-MIST MAY CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT. SKIN
CONTACT MAY CAUSE SLIGHT IRRITATION. INGESTION MAY RESULT IN
VOMITING; ASPIRATION MUST BE AVOIDED (CA USE LUNG DAMAGE-).
NON-IRRITATING ON EYE CONTACT. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALATION-IRRITATION OF UPPER RESPIRATORY
TRACT. SKIN-IRRITATION. INGESTION-VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES-FLUSH WITH WATER. SKIN-FLUSH WITH WATER; THEN WASH WITH
SOAP & WATER. INHALATION-REMOVE TO FRESH AIR. PROVIDE OXYGEN IF
BREATHING DIFFICULT. INGESTED-DO NOT INDUCE VOMITING! GET MEDICAL
ATTENTION .

Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
DO NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:MATERIAL WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE SPACE W/O FULL BUNKER GEAR INCLUDING
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:SOAK UP WITH ABSORBENT SUCH AS CLAY, SAND OR
OTHER SUITABLE MATERIAL. DISPOSE OF IAW LOCAL, STATE AND FEDERAL
REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, OPEN FLAMES AND
OXIDIZING MATERIALS.
Other Precautions:NONE.

Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:CHEMICAL RESISTANT-NITRILE.
Eye Protection:NO SPECIAL PROTECTION REQUIRED.
Other Protective Equipment:AS REQUIRED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health

HCC:N1
Boiling Pt:B.P. Text:400F,204C
Spec Gravity:0.92
Solubility in Water:EMULSIFIABLE
Appearance and Odor:PINK OILY LIQUID; SLIGHT HYDROCARBON ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, OPEN FLAMES, OXIDIZING MATERIALS.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND OTHER,
UNIDENTIFIED ORGANIC COMPUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:PLACE IN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.